Identification and Tabulated Data - TM-5-4120-337-140015

Capacity . . . . . . 9,000 BTU/HR

military model number, federal stock number,

S t o c k Number . . . . . FSN 4120-831-8238

aerial number, specification number, part number,

Manufacturer . . . . . . . Harvey W. Hottel, Inc.

contract number, date, weight and capacity.

(2) C o m p r e s s o r i d e n t i f i c a t i o n p l a t e . L o c a t e d

(2) E v a p o r a t o r a n d c o n d e n s e r f a n m o t o r .

on the front of compressor housing. Specifies

Manufacturer . . . . . . . . Welco Industries

compressor model number, part number, serial

Part Number . . . . . . . . . . . . . 4715-18

Hp (Horsepower) . . . . . . . . . . .86/.10

number, refrigerant, oil type and capacity,

Type . . . . . . . . . . . . . . . . . . . . Double extended shaft

manufacturer and complete electrical data.

Volts . . . . . . . . . . . . . . . . . . 115

(3) F a n m o t o r i d e n t i f i c a t i o n . L o c a t e d o n t o p

Amp (amperes) . . . . . . . . . . 8.0/1.40

o f the fan motor. Specifies motor horsepower, serial

Frequency . . . . . . . . . . . . . . . .60 Hertz

num her, rpm ( r e v o l u t i o n s p e r m i n u t e ) , a n d

Phase . . . . . . . . . . . . . . . . . . . .1

e l e c t r i c a l characteristics.

RPM . . . . . . . . . . . . . . . .3450/1750

Duty . . . . . . . . . . . . . . . . . . . . . Continuous

(4) Control panel legend plate. L o c a t e d o n

Drive . . . . . . . . . . . . . . . . . . . Direct

the front of the unit control panel. Indicates unit

t e r m p e r a t u r e setting for cooling or heating purposes,

(3) P e r f o r m a n c e D a t a .

mode selector switch and fan speed switch.

Cooling Capacity . . . . . . . . . .9,000 BTU/HR nominal

(5) W i r i n g d i a g r a m p l a t e . L o c a t e d o n i n s i d e

9,500 BTU/HR actual at

1 2 0 F DB, Air to Con-

of front access panel, illustrates complete unit

d e n s e r , 90 F DB, 75 F

wiring.

WB, return air to unit.

(6) R e f r i g e r a n t 2 2 p l a t e . L o c a t e d o n t h e r e a r

Heating

Capacity

6,000

BTU/HR

(hi-beat

and

panel in upper left area. It states that the unit is

h i - s p e e d positions) 3,000

charged with 3.31 pounds of refrigerant 22.

BTU/HR (lo-heat and hi-

speed positions)

(7) Color indicating plate. Located on the

rear panel immediately above the liquid line sight

(4) D i m e n s i o n s a n d w e i g h t .

glass. It has three color bands: green, chartreuse,

Length . . . . . . . . . . . . . . . . . 17 in.

a n d yellow which are used in conjunction with the

Width . . . . . . . . . . . . . . . . . . . 17 in.

l i q u i d sight line glass to indicate moisture condition

Height . . . . . . . . . . . . . . . . . .32 1/8 in.

Weight . . . . . . . . . . . . . . . . . 170 lbs.

of the refrigerant.

(8) High and low pressure cutout control reset

(5) E v a p o r a t o r a n d c o n d e n s e r f a n s .

plate. Located on rear panel at the high and low

Manufacturer . . . . . . . Harvey W. Hottel, Inc.

pressure cutout control reset buttons with

Type

Condenser-propeller,

nomenclature: " P U S H T O R E S E T " .

Evaporator-centrifugal

(9) Indicating arrow plate, L o c a t e d o n t h e

Number per unit . . . . . . . .1 each

Rotation (facing condenser

rear panel just above the condenser fan guard; the

air discharge grille) . . Clockwise

a r r o w indicates direction of condenser fan rotation.

(10) C o m p r e s s o r circuit breaker reset

(6) C o m p r e s s o r r e l a y .

plate. Located on the lower right side of the air

Manufacturer . . . . . . . . . . . . Cutler-Hammer

conditioner. It states: " C I R C U I T B R E A K E R

Part Number . . . . . . . . . . . . .MS24192-D1

AMP. . . . . . . . . . . . . . . . . . . . .25

RESET".

Type . . . . . . . . . . . . . . . . . . . . Three pole, single throw

(11) Refrigerant piping plate. Located on

norm ally open

outside of front access panel.

Coil voltage . . . . . . . . . . . . ..28 VDC

(12) Service gage plates, Located beside the

(7) Temperature

control

thermostat.

access cover on the rear panel. They state:

Manufacturer

Penn

Controls

"SUCTION

SERVICE

VALVE"

and

A19AGF-10

Part Number . . . . . . . . .

"DISCHARGE SERVICE VALVE",

Action . . . . . . . . . . . . . . . . . . . Single pole, double throw

(13) C o m p r e s s o r circuit breaker reset

Range . . . . . . . . . . . ..+40 F to 90F

p l a t e . Located on the back of the unit on the CBR

Differential . . . . . . . . . . . . . . 2 F

duct cover. It states: " P U L L A N D P U S H T O

Electrical rating . . . . . . . 5.8 Amps at 120 VAC

RESET CIRCUIT BREAKER".

(8) Mode selector switch.

(14) Damper operation plate. Located on

Manufacturer

Cutler-Hammer

return air grille on front of air conditioner. It

Type . . . . . . . . . . . . . . . . . . Rotary (Manual)

states: "FRESH AIR DAMPER CHAIN PULL

Part Number . . . . . . . . . . . . . 8912K216

TO CLOSE".

Number of positions . . . . . . 5 (hi-heat, lo-heat. off, ven-

b. Tabulated Data.

tilate, cool)

Electrical rating . . . . . . . . 15 amp. 250 VAC

(1) A i r c o n d i t i o n e r i d e n t i f i c a t i o n p l a t e .

Air conditioner . . . . . Vertical. compact, Harvey W.

(9) F a n s p e e d s w i t c h .

Hottel Model CV-9-5/6-15,

Type . . . . . . . . . . . . . . . . . . .. Single pole

Specification

MIL-A-

Part Number . . . . . . . . . MS24523-22

32513A(ME), Class 1, 115

Position . . . . . . . . . . . UP-Hi speed, DOWN-lo speed

Volts A.C., 60 Hertz, 1

Electrical rating . . . . . . . . . . 15 Amps at 28 VDC

phase.

1-5