|
| |
- TECHNICAL MANUAL
- WARNING
- Operator, Organizational,
Direct Support and General Support Maintenance Manual
- Operator, Organizational,
Direct Support and General Support Maintenance Manual
- Operator, Organizational,
Direct Support and General Support Maintenance Manual
- Operator, Organizational,
Direct Support and General Support Maintenance Manual
- TABLE OF CONTENTS
- LIST OF ILLUSTRATIONS
- CHAPTER I. INTRODUCTION
- Figure 1-1. Air Conditioner,
Left Front Three-Quarter View.
- Figure 1-2. Air Conditioner,
Right Rear Three-Quarter View
- Identification and Tabulated
Data
- Identification and Tabulated
Data - continued
- Tabulated Data.
- Difference in Models.
- CHAPTER 2. OPERATING
INSTRUCTIONS
- Stopping
- Operation in Extreme Heat.
- CHAPTER 3. OPERATOR
MAINTENANCE INSTRUCTIONS
- Figure 3-1 Preventive
Maintenance Checks and Services (PMCS)
- Section Ill. Troubleshooting
- Figure 3-2. Air Filter,
Removal and Installation
- Air Filter Inspection and
Service
- CHAPTER 4. ORGANIZATIONAL
MAINTENANCE INSTRUCTIONS
- Figure 4-1. Base Plan.
- Figure 2-4A. Control Box and
Control Box Back Panel, Removal and Installation.
- Figure 2-4B. Control Box and
Control Box Back Panel, Removal and Installation - continued
- Figure 4-2C. Control Box and
Control Box Panel, Removal and lnstallation (Continued).
- Power Sources.
- Section III. Repair Parts,
Special Tools, and Equipment
- Figure 4-3. Preventive
Maintenance Checks and Services (PMCS)
- Sections VI. Troubleshooting
- Table 4-2. Troubleshooting
- Figure 4-4. F r e s h Air
Inlet Screen, Chemical and Biological Inlet Cover,Condenser Fan
Guard, and Condenser Coil Grille, Removal and Installation.
- Figure 4-5. Discharge Intake
Grille, Front Access Panel, Removal and Installation
- Top Panel, Discharge Grille,
Intake Grille, and Front Access Panel
- Figure 4-6. Fan Motor,
Removal and Installation
- Capacitors (Model VM 6000-115
only).
- Thermostat.
- Figure 4-7. Compressor,
Pressure Relief Valve, Receive, Liquid Line Solenoid Valve,
Filter-Driver, Drain Tube, Removal and Installation
- Figure 4-8. Evaporator Fan,
Inlet Ring and Thermostat Sensing Bulb, Removal and Installation
- Figure 4-9. Condenser Fan,
Removal and Installation
- Figure 4-10. Moel VM 6000-115
Heating Element Evaporator Coil, Expansion Valve, Fan Motor Relay,
Equilizer soilenoid Valves, Pressure Regukating Valve, Diode Surge
Protector, Heater Thermostat, Removal and Installation
- Figure 4-11 Model VM6000-400
Heating Element, Fan Speed Pressure Switch, Expansion Valve, Surge
Protector, Heater Thermostat, Removal and Installation
- Figure 4-12 Junction Box,
Fuses, Rectifier, Time Delay, Terminal Board Heater Relay,
Compressor Motor Relay, Circuit Breaker Phase Sequence Relay,
Removal and Installation
- Circuit Breaker.
- High Pressure Switch.
- Figure 4-13. High and Low
Pressure Switches, Sight Glass, Ouside Air Thermostat, Removal and
Installation
- Refrigerant Piping.
- Expansion Valves.
- Drain Tubes.
- CHAPTER 5. DIRECT SUPPORT AND
GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
- Table 5-1. Troubleshooting
- System Losing Cooling
Capacity
- Cooling Cycle of Operation.
- Sight glass method.
- Wiring Harness and Wire
Leads.
- Installation.
- Chapter 6. Repair of Air
Conditioner
- High Pressure Switch.
- Figuire 6-1. Solenoid Valve,
Disassembly and Reassembly.
- Equalizer Solenoid Valve.
- Filter Drier.
- Appendix A. REFERENCES
- Appendix B. MAINTENANCE
ALLOCATION CHART
- Column Entries Used in the
MAC.
- Repair Parts List
- Repair Parts List
- Repair Parts List
- Section III. Tools and Test
Equipment Requirements
- Figure 1-3. Wiring Digram
Model VM 6000 208
- Figure 1-4. Wiring Digram
Model VM 6000-115
- Figure 5-1. Refrigerant Flow
Diagram
- The Metric System and
Equivalents
- RECOMMENDED CHANGES TO
EQUIPMENT TECHNICAL MANUALS
- Blank Page
- TM-5-4120-355-14
- Blank Page
- Blank Page
- RECOMMENDED CHANGES TO
EQUIPMENT TECHNICAL MANUALS
- Blank Page
- Blank Page
- REVERSE OF DA FORM 2028-2
- Blank Page
- RECOMMENDED CHANGES TO
EQUIPMENT TECHNICAL MANUALS
- RECOMMENDED CHANGES TO
EQUIPMENT TECHNICAL MANUALS
- Blank Page
- REVERSE OF DA FORM 2028-2
- Blank Page
- RECOMMENDED CHANGES TO
EQUIPMENT TECHNICAL MANUALS
- REVERSE OF DA FORM 2028-2
- REVERSE OF DA FORM 2028-2
- Blank Page
- Blank page
- Blank Page
- Blank Page
- REVERSE OF DA FORM 2028-2
- Blank Page
- Blank Page
- Blank Page
|
|
Click
here for thousands of PDF manuals