TM 10-8145-222-23
0058
REPAIR CONTINUED
Replace Fuel Tank Cap
WARNING
The JP-8 and diesel fuels used with the MTRCS are combustible and highly
explosive. Do not smoke or use open flame when performing maintenance. Flames
and explosion can occur resulting in severe injury or death.
The JP-8 and diesel fuels used with the MTRCS are toxic. Always wear eye, face,
and hand protection when working with or around fuel. If fuel contact is made with
eyes, flush your eyes and seek immediate medical attention. If fuel contact is made
with skin or clothing, remove contaminated clothing immediately, clean your skin with
a mild soap or cleanser, and rinse with clean water.
CAUTION
Use cleaning rags or spill kit to clean up any spills when performing the following
tasks.
1. Disconnect battery (WP 0053, Disconnect).
NOTE
The fuel tank cap is attached to the fuel tank with a short chain.
2. Remove fuel tank cap (Figure 4, Item 1) from fuel tank (Figure 4, Item 2) by turning counterclockwise and lifting.
3. Allow fuel tank cap (Figure 4, Item 1) to rest on top of fuel tank (Figure 4, Item 2), then unhook and remove fuel
tank cap (Figure 4, Item 1) from chain (Figure 4, Item 3).
4. Install replacement fuel tank cap (Figure 4, Item 1) and hook into place on chain (Figure 4, Item 3).
5. Install replacement cap (Figure 4, Item 1) onto fuel tank (Figure 4, Item 2) and turn in clockwise direction to lock
in place.
6. Connect battery (WP 0053, Reconnect).
7. Place MTRCS back into desired mode of operation (TM 10-8415-222-10, Operating Procedures).
0058-11