TM 10-8145-222-23
0028
REPLACE CONTINUED
16. Install two bolts (Figure 3, Item 4) to secure thermostat cover (Figure 3, Item 3) to engine (Figure 3, Item 5).
17. Tighten bolts to 15-22 foot-pounds (WP 0091, Introduction).
NOTE
Make sure hose clamp is slid over top radiator hose before connecting top radiator
hose to thermostat cover.
18. Reconnect top radiator hose (Figure 3, Item 2) to thermostat cover (Figure 3, Item 3).
19. Position hose clamp (Figure 3, Item 1) and tighten.
20. Place emergency stop switch (Figure 2, Item 1) in PULL TO START position.
21. Climb off of MTRCS using roof access provided.
22. Place POWER ON/DOWN switch (Figure 1, Item 2) on control panel to ON position.
WARNING
Approved hearing protection must be worn when operating the MTRCS diesel
engine. Failure to observe this precaution may result in severe and permanent
hearing loss.
23. Start diesel engine (TM 10-8415-222-10, Operating Procedures).
WARNING
Falling from the roof of the MTRCS can cause serious personal injury or death. Keep
three points of contact on the MTRCS at all times.
24. Access top of MTRCS using roof access provided.
25. Check thermostat cover (Figure 3, Item 3), top radiator hose (Figure 3, Item 2), and surrounding area for
coolant fluid leaks.
26. Climb off of MTRCS using roof access provided.
27. Place POWER ON/DOWN switch on control panel to DOWN position.
28. Close control panel access door (Figure 1, Item 1).
29. Shut diesel engine down (TM 10-8415-222-10, Operating Procedures).
WARNING
Falling from the roof of the MTRCS can cause serious personal injury or death. Keep
three points of contact on the MTRCS at all times.
The refrigeration unit can start automatically causing drive components and fans to
operate unannounced. Unit operation must be prevented to avoid personal injury.
30. Access top of MTRCS using roof access provided.
0028-4
