Click here to make tpub.com your Home Page

Page Title: TM-5-4120-384-14

• OPERATOR'S, ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL
• AIR CONDITIONER, HORIZONTAL COMPACT
• By Order of the Secretary of the Army:
• AIR CONDITIONER, HORIZONTAL COMPACT,
• By Order of the Secretary of the Army:
• AIR CONDITIONER, HORIZONTAL COMPACT,
• AIR CONDITIONER, HORIZONTAL COMPACT,
• AIR CONDITIONER, HORIZONTAL COMPACT,
• By Order of the Secretary of the Army:
• AIR CONDITIONER, HORIZONTAL, COMPACT,
• By Order of the Secretary of the Army:
• Warning
• Warning (Cont)
• Warning (Cont)
• TABLE OF CONTENTS
• TABLE OF CONTENTS - Continued
• LIST OF ILLUSTRATIONS
• LIST OF ILLUSTRATIONS (Cont)
• LIST OF TABLES
• Figure 1-1. Air Conditioner
• Chapter 1. INTRODUCTION
• REPORTING EQUIPMENT IMPROVEMENT RECOMMENDATIONS (EIR8).
• LOCATION AND DESCRIPTION OF MAJOR COMPONENTS.
• Figure 1-2. Location of Major Components (Sheet 1 of 2)
• Figure 1-2. Location of Major Components (Sheet 2 of 2)
• LOCATION AND DESCRIPTION OF MAJOR COMPONENTS.-Continued
• LOCATION AND DESCRIPTION OF MAJOR COMPONENTS.-Continued
• LOCATION AND DESCRIPTION OF MAJOR COMPONENTS.-Continued
• DIFFERENCES BETWEEN MODELS
• Figure 1-2.1 Electromagnetic Pulse (EMP) Kit Parts
• EQUIPMENT DATA
• Figure 1-3. Refrigeration Schematic
• REFRIGERATION CYCLE.
• REFRIGERATION CYCLE.-Continued
• Chapter 2. OPERATING INSTRUCTIONS
• OPERATOR'S CONTROLS.
• Figure 2-1. Operator's Controls and Indicators
• Figure 2-2. Operator's Controls and Indicators
• INDICATORS.
• Section II: PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
• Table 2-1. OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES
• Table 2-1. OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (Cont)
• Section III OPERATION UNDER USUAL CONDITIONS.
• OPERATIONAL CHECKS.
• OPERATIONAL CHECKS.-Continued
• GENERAL OPERATING PROCEDURES.
• Table 2-2 INITIAL OPERATOR CONTROL SETTINGS
• INFORMATION PLATES.
• PREPARATION FOR MOVEMENT.
• OPERATION IN EXTREME COLD.
• OPERATION IN DUSTY OR SANDY CONDITIONS
• OPERATION IN SALT AIR OR SEA SPRAY.
• Chapter 3. OPERATOR'S MAINTENANCE INSTRUCTIONS
• Table 3-1. OPERATOR TROUBLESHOOTING
• REDUCED HEATING CAPACITY.
• TOO MUCH HEAT.
• Chapter 4: ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
• Section I. REPAIR PARTS, SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT
• Section II: SERVICE UPON RECEIPT OF EQUIPMENT
• Figure 4-1. Installation Dimensions (Sheet 1 of 6)
• Figure 4-1. Installation Dimensions (Sheet 2 of 6)
• Figure 4-1. Installation Dimensions (Sheet 3 of 6)
• Figure 4-1. Installation Dimensions (Sheet 4 of 6)
• Figure 4-1. Installation Dimensions (Sheet 5 of 6)
• Figure 4-1. Installation Dimensions (Sheet 6 of 6)
• SERVICE UPON RECEIPT OF MATERIAL.
• SERVICE UPON RECEIPT OF MATERIAL. (cont)
• INSTALLATION INSTRUCTIONS.
• Figure 4-2. Wiring Connection Changes for J1/J11 Power Input Connector
• INSTALLATION INSTRUCTIONS.-Continued
• INSTALLATION INSTRUCTIONS.-Continued
• Figure 4-4. Wiring Diagram (Sheet 1 of 12)
• Figure 4-4. Wiring Diagram (Sheet 2 of 12)
• Figure 4-4. Wiring Diagram (Sheet 3 of 12)
• Figure 4-4. Wiring Diagram (Sheet 4 of 12)
• Figure 4-4. Wiring Diagram (Sheet 5 of 12)
• Figure 4-4. Wiring Diagram (Sheet 6 of 12)
• Figure 4-4. Wiring Diagram (Sheet 7 of 12)
• Figure 4-4. Wiring Diagram (Sheet 8 of 12)
• Figure 4-4. Wiring Diagram (Sheet 9 of 12)
• Figure 4-4. Wiring Diagram (Sheet 10 of 12)
• Figure 4-4. Wiring Diagram (Sheet 11 of 12)
• Figure 4-4. Wiring Diagram (Sheet 12 of 12)
• Figure 4-4.1 . Air Conditioner Schematic
• INSTALLATION INSTRUCTIONS.-Continued
• INSTALLATION INSTRUCTIONS.-Continued
• PRELIMINARY SERVICING AND ADJUSTMENT OF EQUIPMENT.
• Section III: PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
• Figure 4-6. Location of PMCS Items
• Table 4-1. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) QUARTERLY SCHEDULE
• Table 4-1. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) QUARTERLY SCHEDULE (Cont)
• Table 4-1. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) QUARTERLY SCHEDULE (Cont)
• Table 4-1. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) QUARTERLY SCHEDULE (Cont)
• Table 4-1. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) QUARTERLY SCHEDULE (Cont)
• Table 4-1. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) QUARTERLY SCHEDULE (Cont)
• Table 4-1. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) QUARTERLY SCHEDULE (Cont)
• Table 4-2. TROUBLESHOOTING
• CONDITIONED (EVAPORATOR) AIR FAN DOES NOT START OR STOPS DURING OPERATION IN ANY MODE.
• CONDENSER FAN FAILS TO OPERATE.
• INSUFFICIENT COOLING.
• COMPRESSOR WILL NOT START.
• COMPRESSOR STARTS, BUT GOES OUT ON OVERLOAD.
• CONDENSER AIR OUTLET VOLUME LOW.
• EXCESSIVE NOISE .
• Section V MAINTENANCE PROCEDURES
• FABRIC COVER
• TOP COVERS.
• TOP COVERS. - Continued
• TOP COVERS. - Continued
• Figure 4-9. Rear Screens
• SCREENS AND GUARDS.
• RETURN AIR LOUVER AND AIR FILTER.
• Figure 4-10. Return Air Louver and Air Filter
• RETURN AIR LOUVER AND AIR FILTER.-Continued
• SUPPLY AIR LOUVER-
• SUPPLY AIR LOUVER.-Continued
• MIST ELIMINATOR.
• MIST ELIMINATOR. - Continued
• CONDENSER AIR DISCHARGE LOUVER AND LINKAGE.
• Figure 4-13. Condenser Air Discharge Louver and Linkage
• CONDENSER AIRE DISCHARGE LOUVER AND LINKAGE. - Continued
• CONDENSER AIRE DISCHARGE LOUVER AND LINKAGE. - Continued
• FRESH AIR DAMPER AND ACTUATOR.
• FRESH AIR DAMPER AND ACTUATOR. - Continued
• FRESH AIR DAMPER AND ACTUATOR. - Continued
• CONDENSATE DRAIN.
• Figure 4-15. Condensate Drain Lines
• ELECTRICAL WIRING REPAIR - GENERAL .
• Table 4-3. WIRE LIST
• Table 4-3. WIRE LIST (cont)
• Table 4-3. WIRE LIST (cont)
• Table 4-3. WIRE LIST (cont)
• CONTROL MODULE.
• CONTROL MODULE. - Continued
• Figure 4-17. Control Module
• TEMPERATURE SELECTOR (CONTROL SWITCH THERMOSTAT) S3.
• Figure 4-18. TEMPERATURE SELECTOR (Control Switch Thermostat) S3
• MODE SELECTOR SWITCH S1.
• Figure 4-19. MODE SELECTOR Switch S1
• MODE SELECTOR SWITCH S1. - Continued
• MODE SELECTOR SWITCH S1. - Continued
• Figure 4-20. COMPR CIRCUIT BKR (Compressor Circuit Breaker) CB1
• COMPR CIRCUIT BKR CB1
• CONTROL MODULE WIRING HARNESS.
• CONTROL MODULE WIRING HARNESS. - Continued
• JUNCTION BOX.
• Figure 4-22. Junction Box
• JUNCTION BOX WIRING HARNESS.
• JUNCTION BOX WIRING HARNESS. - Continued
• RELAY.
• RELAY. (cont)
• RELAY. (cont)
• CONTROL CIRCUIT BREAKER CB2.
• CONTROL CIRCUIT BREAKER CB2. - Continued
• MISCELLANEOUS CABLES, HARNESSES, AND TERMINAL BOARDS.
• Figure 4-26. Miscellaneous Cables, Harnesses, Terminal Boards
• TRANSFORMER, RECTIFIER, CAPACITORS, MD HARNESS.
• Figure 4-27. Transformer and Rectifier
• TRANSFORMER, RECTIFIER, CAPACITORS, AND
• TRANSFORMER, RECTIFIER, COMPACTORS, AND HARNESS
• TRANSFORMER, RECTIFIER, CAPACITORS, AND HARNESS.-Continued
• Figure 4-27.1 Capacitors and Relay, Model F18H-1S only
• 4-31.1. (MODEL F18H-1S ONLY) CAPACITORS - CONDENSER RUN (C-2), EVAPORATOR RUN (C-3), COMPRESSOR START (C4), COMPRESSOR RUN (C-5) AND RELAY; COMPRRSSOR START (KS).
• 4-31.1. (MODEL F18H-1S ONLY) CAPACITORS - CONDENSER RUN (C-2), EVAPORATOR RUN (C-3), COMPRESSOR START (C4), COMPRESSOR RUN (C-5) AND RELAY; COMPRRSSOR START (KS). (Cont)
• EVAPORATOR FAN, MOTOR, AND HOUSING.
• Figure 4-28 Evaporator Fan, Motor, and Housing
• EVAPORATOR FAN, MOTOR, AND HOUSING.-Continued
• EVAPORATOR FAN, MOTOR, AND HOUSING.-Continued
• EVAPORATOR FAN, MOTOR, AND HOUSING.-Continued
• HEATER THERMOSTAT.
• HEATER THERMOSTAT.-Continued
• HEATER ELEMENTS.
• Figure 4-30. Heater Elements
• HEATER ELEMENTS. (Cont)
• CONDENSER FAN, MOTOR, AND HOUSIING.
• Figure 4-31. Condenser Fan, Motor, and Housing
• CONDENSER FAN, MOTOR, AND HOUSIING. (Cont)
• CONDENSER FAN, MOTOR, AND HOUSIING. (Cont)
• CONDENSER FAN, MOTOR, AND HOUSIING. (Cont)
• EVAPORATOR COIL (CLEANING).
• Figure 4-32. Evaporator Coil
• SOLENOID VALVE (COIL REMOVAL).
• Figure 4-33. Solenoid Valve Coil Removal
• SOLENOID VALVE (COIL REMOVAL).-Continued
• LOW PRESSURE CUTOUT SWITCH (LPCO) JUMPER.
• Figure 4-34. Jumper Across LPCO Switch
• CONDENSER COIL (CLEANING).
• Figure 4-35. Condenser Coil
• CONDENSER COIL (CLEANING). (cont)
• CONNECTORS (INSTALLATION).
• CONNECTORS (INSTALLATION).Continued
• INSTALLATION HARDWARE.
• Section VI: PREPARATION FOR STORAGE OR SHIPMENT
• Chapter 5: DIRECT SUPPORT MAINTENANCE INSTRUCTIONS
• Section I: REPAIR PARTS, SPECIAL TOOLS~ TMDE~ AND SUPPORT EQUIPMENT
• Section II: TROUBLESHOOTING
• Table 5-1. TROUBLESHOOTING
• COMPRESSOR SHORT CYCLES.
• COMPRESSOR SHORT CYCLES. (Cont)
• INSUFFICIENT COOLING ACTION.
• INSUFFICIENT COOLING ACTION. (Cont)
• REFRIGERANT SYSTEM CONTINUOUSLY LOSING REFRIGERANT.
• UNIT OPERATES CONTINUOUSLY ON COOLING CYCLE.
• AIR CONDITIONER NOISY DURING OPERATION.
• Section III: MAINTENANCE PROCEDURES
• SCREENS, GUARDS, AND LOUVERS.
• INFORMATION PLATES.
• EVAPORATOR, FAN, MOTOR, AND HOUSING REPAIR.
• Figure 5-1. Motor  Assembly, Custom Motor Design
• EVAPORATOR, FAN, MOTOR, AND HOUSING REPAIR. (Cont)
• Figure 5-11. Motor  Assembly,  Keco  Industries,
• EVAPORATOR, FAN, MOTOR, AND HOUSING REPAIR. (Cont)
• CONDENSER FAN, HOTOR, AND HOUSING REPAIR.
• CONDENSER FAN, MOTOR, AND HOUSING REPAIR.-Continued
• CONDENSER FAN, MOTOR, AND HOUSING REPAIR.-Continued
• CONDENSER FAN, MOTOR, AND HOUSING REPAIR.-Continued
• CONDENSER FAN, MOTOR, AND HOUSING REPAIR.-Continued
• CONDENSER FAN, MOTOR, AND HOUSING REPAIR.-Continued
• CONDENSER FAN, MOTOR, AND HOUSING REPAIR.-Continued
• REFRIGERATION SYSTEM REPAIRS GENERAL.
• DISCHARGING THE REFRIGERANT SYSTEM.
• DISCHARGING THE REFRIGERANT SYSTEM. - Continued
• PURGING THE REFRIGERANT SYSTEM.
• PURGING THE REFRIGERANT SYSTEM. (Cont)
• BRAZING/DEBRAZING PROCEDURES.
• BRAZING/DEBRAZING PROCEDURES.-Continued
• LEAK TESTING.
• LEAK TESTING. (Cont)
• LEAK TESTING. (Cont)
• EVACUATING TEE REFRIGERANT SYSTEM.
• EVACUATING THE REFRIGERANT SYSTEM. - Continued
• CHARGING THE REFRIGERANT SYSTEM
• CHARGING THE REFRIGERANT SYSTEM.-Continued
• CHARGING THE REFRIGERANT SYSTEM.-Continued
• REFRIGERATION SYSTEM TROUBLESHOOTING.
• OVEREEATING CHECKS.
• REFRIGERANT PRESSURE CHECK.
• Table 5-2. PRESSURE-TEMPERATURE RELATIONSHIP OF SATURATED REFRIGERANT-22
• Table 5-3. NORMAL OPERATING PRESSURES
• EVAPORATOR COIL.
• EVAPORATOR COIL. -Continued
• EVAPORATOR COIL.-Continued
• FLUID FLOW RESTRICTOR.
• FLUID FLUID RESTRICTOR.-Continued
• EXPANSION VALUE (PRIMARY).
• Figure 5-10. Expansion Valve (Primary)
• EXPANSION VALVE (QUENCH).
• Figure 5-11. Expansion Valve (Quench)
• EXPANSION VALVE (QUENCH).-Continued
• SOLENOID VALVES.
• Figure 5-12. Solenoid Valves
• PRESSURE REGULATOR.
• Figure 5-13. Pressure Regulator
• ACTUATING CYLINDER.
• Figure 5-14. Actuating Cylinder
• PRESSURE SWITCHES.
• Figure 5-15. Pressure Switches
• PRESSURE SWITCHES. (Cont)
• SERVICE (CHARGING) VALVES.
• Figure 5-16. Service (Charging) Valves
• PRESSURE RELIEF VALVE.
• Figure 5-17. Pressure Relief Valve
• Condenser Coil
• Figure 5-18. Condenser Coil
• Condenser Coil (cont)
• DEHYDRATOR (FILTER/DRIER).
• Figure 5-19. Dehydrator (Filter/Drier)
• LIQUID INDICATOR (SIGHT GLASS).
• Figure 5-20. LIQUID INDICATOR .
• Compressor
• Figure 5-21. Compressor
• Compressor (cont)
• Compressor (cont)
• Compressor (cont)
• Compressor (cont)
• Figure 5-22. Refrigerant Flow System with Dehydrator and Compressor Removed
• COMPRESSOR.-Continued
• COMPRESSOR.-Continued
• COMPRESSOR.-Continued
• COMPRESSOR.-Continued
• TUBING AND FITTINGS.
• Chapter 6. GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
• Housing
• HOUSING.-Continued
• Appenidx A: REFERENCES
• SPECIFICATIONS.
• Appendix B: MAINTENANCE ALLOCATION CHART
• MAINTENANCE FUNCTIONS
• EXPLANATION OF COLUMNS IN THE MAC, SECTION II.
• EXPLANATION OF COLUMNS IN REMARKS, SECTION IV.
• Section II: MAINTENANCE ALLOCATION CHART
• Section II: MAINTENANCE ALLOCATION CHART (cont)
• Section II: MAINTENANCE ALLOCATION CHART (cont)
• Section II: MAINTENANCE ALLOCATION CHART (cont)
• Section II: MAINTENANCE ALLOCATION CHART (cont)
• Section II: MAINTENANCE ALLOCATION CHART (cont)
• Section III. TOOL AND TEST EQUIPMENT REQUIREMENTS MAINTENANCE ALLOCATION CHART
• Section IV: REMARKS MAINTENANCE ALLOCATION CHART
• Appendix C: COMPONENTS OF END ITEM AND BASIC ISSUE ITEMS LISTS
• EXPLANATION OF COLUMNS.
• Section II: COMPONENTS OF END ITEM
• Section III: BASIC ISSUE ITEMS
• Appendix D: ADDITIONAL AUTHORIZATION LIST
• Appendix E: EXPENDABLE SUPPLIES AND MATERIALS LIST
• Section II EXPENDABLE SUPPLIES AND MATERIALS LIST
• GLOSSARY
• INDEX
• 'TM 5-4120-384-14' by LOGSA - Page 1 of 318
• INDEX (Cont)
• INDEX (Cont)
• INDEX (Cont)
• The Metric System and Equivalents
• Blank Page
• TM-5-4120-384-14
• Recommended Changes to Equipment Technical Publications
• Blank Page
• By Order of the Secretary of the Army:
• Blank Page
• Recommended Changes to Equipment Technical Publications